Kia Sportage: Air conditioning System / Refrigerant Line Repair procedures

Kia Sportage QL (2015-2026) Service Manual / Heating,Ventilation And Air Conditioning / Air conditioning System / Refrigerant Line Repair procedures

Replacement

1.	Discharge refrigerant from the refrigeration system.

Replace faulty tube or hose.

Cap the open fittings immediately to keep moisture or dirt out of the system.

Tighten the bolt or nut joint to the specified torque.

Connections should not be tightened to exceed the specified torque.

Evacuate air in the refrigeration system and charge system with refrigerant.

Specified amount

550 ± 25g (19.4 ± 0.88 oz.)

5.	Inspect for leakage of refrigerant. Using a gas leak detector, check for refrigerant leakage.

6.	Inspect A/C operation.

Compressor oil Repair procedures

Oil Specification 1. The HFC-134a system requires synthetic (PAG) compressor oil whereas the R-12 system requires mineral compressor oil. The two oils must never ...

Compressor Components and components location

Component Location 1. Compressor Components [THETA Engine] 1. Clutch Bolt 2. Limiter Bolt 3. Limiter &am ...

Other information:

Kia Sportage QL (2015-2026) Service Manual: Front Wheel Speed Sensor Components and components location

Components 1. Front wheel speed sensor cable 2. Front wheel speed sensor ...

Kia Sportage QL (2015-2026) Service Manual: Seat Heater Switch Repair procedures

Removal [Front Seat] 1. Disconnect the negative (-) battery terminal. 2. Remove the center fascia lower panel. (Refer to body - "Center Fascia Panel") 3. Using a flat-tip screwdriver ...